Cybersecurity and privacy risk assessment of point-of-care systems in healthcare: A use case approach
Contents
A thin-film transistor (TFT) is a special type of field-effect transistor (FET) where the transistor is made by thin film deposition. TFTs are grown on a supporting (but non-conducting) substrate, such as glass. This differs from the conventional bulk metal oxide field effect transistor (MOSFET), where the semiconductor material typically is the substrate, such as a silicon wafer.[1] The traditional application of TFTs is in TFT liquid-crystal displays.
Design and manufacture
TFTs can be fabricated with a wide variety of semiconductor materials. Because it is naturally abundant and well understood, amorphous or polycrystalline silicon were (and still are) used as the semiconductor layer. However, because of the low mobility of amorphous silicon[2] and the large device-to-device variations found in polycrystalline silicon,[3][4][5] other materials have been studied for use in TFTs. These include cadmium selenide,[6][7] metal oxides such as indium gallium zinc oxide (IGZO) or zinc oxide,[8] organic semiconductors,[9] carbon nanotubes,[10] or metal halide perovskites.[11]
![](http://upload.wikimedia.org/wikipedia/commons/thumb/b/bb/Four_Thin_Film_Transistor_Architectures.png/300px-Four_Thin_Film_Transistor_Architectures.png)
Because TFTs are grown on inert substrates, rather than on wafers, the semiconductor must be deposited in a dedicated process. A variety of techniques are used to deposit semiconductors in TFTs. These include chemical vapor deposition (CVD), atomic layer deposition (ALD), and sputtering. The semiconductor can also be deposited from solution,[12] via techniques such as printing[13] or spray coating.[14] Solution-based techniques are hoped to lead to low-cost, mechanically flexible electronics.[15] Because typical substrates will deform or melt at high temperatures, the deposition process must be carried out under relatively low temperatures compared to traditional electronic material processing.[16]
Some wide band gap semiconductors, most notable metal oxides, are optically transparent.[17] By also employing transparent substrates, such as glass, and transparent electrodes, such as indium tin oxide (ITO), some TFT devices can be designed to be completely optically transparent.[18] Such transparent TFTs (TTFTs) could be used to enable head-up displays (such as on a car windshield).The first solution-processed TTFTs, based on zinc oxide, were reported in 2003 by researchers at Oregon State University.[19] The Portuguese laboratory CENIMAT at the Universidade Nova de Lisboa has produced the world's first completely transparent TFT at room temperature.[20] CENIMAT also developed the first paper transistor,[21] which may lead to applications such as magazines and journal pages with moving images.
Many AMOLED displays use LTPO (Low-temperature Poly-Crystalline Silicon and Oxide) TFT transistors. These transistors offer stability at low refresh rates, and variable refresh rates, which allows for power saving displays that do not show visual artifacts.[22][23][24] Large OLED displays usually use AOS (amporphous oxide semiconductor) TFT transistors instead, also called oxide TFTs[25] and these are usually based on IGZO.[26]
Applications
The best known application of thin-film transistors is in TFT LCDs, an implementation of liquid-crystal display technology. Transistors are embedded within the panel itself, reducing crosstalk between pixels and improving image stability.
As of 2008, many color LCD TVs and monitors use this technology. TFT panels are frequently used in digital radiography applications in general radiography. A TFT is used in both direct and indirect capture[jargon] as a base for the image receptor in medical radiography.
As of 2013, all modern high-resolution and high-quality electronic visual display devices use TFT-based active matrix displays.[27]
AMOLED displays also contain a TFT layer for active-matrix pixel addressing of individual organic light-emitting diodes.
The most beneficial aspect of TFT technology is its use of a separate transistor for each pixel on the display. Because each transistor is small, the amount of charge needed to control it is also small. This allows for very fast re-drawing of the display.
Structure of a TFT-display matrix
This picture does not include the actual light-source (usually cold-cathode fluorescent lamps or white LEDs), just the TFT-display matrix.
History
In February 1957, John Wallmark of RCA filed a patent for a thin film MOSFET in which germanium monoxide was used as a gate dielectric. Paul K. Weimer, also of RCA implemented Wallmark's ideas and developed the thin-film transistor (TFT) in 1962, a type of MOSFET distinct from the standard bulk MOSFET. It was made with thin films of cadmium selenide and cadmium sulfide. In 1966, T.P. Brody and H.E. Kunig at Westinghouse Electric fabricated indium arsenide (InAs) MOS TFTs in both depletion and enhancement modes.[28][29][30][31][32][33]
The idea of a TFT-based liquid-crystal display (LCD) was conceived by Bernard J. Lechner of RCA Laboratories in 1968.[34] Lechner, F.J. Marlowe, E.O. Nester and J. Tults demonstrated the concept in 1968 with an 18x2 matrix dynamic scattering LCD that used standard discrete MOSFETs, as TFT performance was not adequate at the time.[35] In 1973, T. Peter Brody, J. A. Asars and G. D. Dixon at Westinghouse Research Laboratories developed a CdSe (cadmium selenide) TFT, which they used to demonstrate the first CdSe thin-film-transistor liquid-crystal display (TFT LCD).[31][36] The Westinghouse group also reported on operational TFT electroluminescence (EL) in 1973, using CdSe.[37] Brody and Fang-Chen Luo demonstrated the first flat active-matrix liquid-crystal display (AM LCD) using CdSe in 1974, and then Brody coined the term "active matrix" in 1975.[34] However, mass production of this device was never realized, due to complications in controlling the compound semiconductor thin film material properties, and device reliability over large areas.[31]
A breakthrough in TFT research came with the development of the amorphous silicon (a-Si) TFT by P.G. le Comber, W.E. Spear and A. Ghaith at the University of Dundee in 1979. They reported the first functional TFT made from hydrogenated a-Si with a silicon nitride gate dielectric layer.[31][38] The a-Si TFT was soon recognized as being more suitable for a large-area AM LCD.[31] This led to commercial research and development (R&D) of AM LCD panels based on a-Si TFTs in Japan.[39]
By 1982, pocket TVs based on AM LCD technology were developed in Japan.[40] In 1982, Fujitsu's S. Kawai fabricated an a-Si dot-matrix display, and Canon's Y. Okubo fabricated a-Si twisted nematic (TN) and guest-host LCD panels. In 1983, Toshiba's K. Suzuki produced a-Si TFT arrays compatible with CMOS (complementary metal–oxide–semiconductor) integrated circuits (ICs), Canon's M. Sugata fabricated an a-Si color LCD panel, and a joint Sanyo and Sanritsu team including Mitsuhiro Yamasaki, S. Suhibuchi and Y. Sasaki fabricated a 3-inch a-SI color LCD TV.[39]
The first commercial TFT-based AM LCD product was the 2.1-inch Epson[41][42][43] ET-10[37] (Epson Elf), the first color LCD pocket TV, released in 1984.[44] In 1986, a Hitachi research team led by Akio Mimura demonstrated a low-temperature polycrystalline silicon (LTPS) process for fabricating n-channel TFTs on a silicon-on-insulator (SOI), at a relatively low temperature of 200 °C.[45] A Hosiden research team led by T. Sunata in 1986 used a-Si TFTs to develop a 7-inch color AM LCD panel,[46] and a 9-inch AM LCD panel.[47] In the late 1980s, Hosiden supplied monochrome TFT LCD panels to Apple Computer.[31] In 1988, a Sharp research team led by engineer T. Nagayasu used hydrogenated a-Si TFTs to demonstrate a 14-inch full-color LCD display,[34][48] which convinced the electronics industry that LCD would eventually replace cathode-ray tube (CRT) as the standard television display technology.[34] The same year, Sharp launched TFT LCD panels for notebook PCs.[37] In 1992, Toshiba and IBM Japan introduced a 12.1-inch color SVGA panel for the first commercial color laptop by IBM.[37]
TFTs can also be made out of indium gallium zinc oxide (IGZO). TFT-LCDs with IGZO transistors first showed up in 2012, and were first manufactured by Sharp Corporation. IGZO allows for higher refresh rates and lower power consumption.[49][50] In 2021, the first flexible 32-bit microprocessor was manufactured using IGZO TFT technology on a polyimide substrate.[51]
See also
References
- ^ Sze, S.M.; Ng, Kwok K. (2006-04-10). Physics of Semiconductor Devices. doi:10.1002/0470068329. ISBN 9780470068328.
- ^ Powell, M.J. (1989). "The physics of amorphous-silicon thin-film transistors". IEEE Transactions on Electron Devices. 36 (12): 2753–2763. Bibcode:1989ITED...36.2753P. doi:10.1109/16.40933. ISSN 1557-9646.
- ^ Rana, V.; Ishihara, R.; Hiroshima, Y.; Abe, D.; Inoue, S.; Shimoda, T.; Metselaar, W.; Beenakker, K. (2005). "Dependence of single-crystalline Si TFT characteristics on the channel position inside a location-controlled grain". IEEE Transactions on Electron Devices. 52 (12): 2622–2628. Bibcode:2005ITED...52.2622R. doi:10.1109/TED.2005.859689. ISSN 1557-9646. S2CID 12660547.
- ^ Kimura, Mutsumi; Nozawa, Ryoichi; Inoue, Satoshi; Shimoda, Tatsuya; Lui, Basil; Tam, Simon Wing-Bun; Migliorato, Piero (2001-09-01). "Extraction of Trap States at the Oxide-Silicon Interface and Grain Boundary for Polycrystalline Silicon Thin-Film Transistors". Japanese Journal of Applied Physics. 40 (9R): 5227. Bibcode:2001JaJAP..40.5227K. doi:10.1143/jjap.40.5227. ISSN 0021-4922. S2CID 250837849.
- ^ Lui, Basil; Tam, S. W.-B.; Migliorato, P.; Shimoda, T. (2001-06-01). "Method for the determination of bulk and interface density of states in thin-film transistors". Journal of Applied Physics. 89 (11): 6453–6458. Bibcode:2001JAP....89.6453L. doi:10.1063/1.1361244. ISSN 0021-8979.
- ^ Brody, T. Peter (November 1984). "The Thin Film Transistor - A Late Flowering Bloom". IEEE Transactions on Electron Devices. 31 (11): 1614–1628. Bibcode:1984ITED...31.1614B. doi:10.1109/T-ED.1984.21762. S2CID 35904114.
- ^ Brody, T. Peter (1996). "The birth and early childhood of active matrix - a personal memoir". Journal of the SID. 4/3: 113–127.
- ^ Petti, Luisa; Münzenrieder, Niko; Vogt, Christian; Faber, Hendrik; Büthe, Lars; Cantarella, Giuseppe; Bottacchi, Francesca; Anthopoulos, Thomas D.; Tröster, Gerhard (2016-06-01). "Metal oxide semiconductor thin-film transistors for flexible electronics". Applied Physics Reviews. 3 (2): 021303. Bibcode:2016ApPRv...3b1303P. doi:10.1063/1.4953034. hdl:20.500.11850/117450.
- ^ Lamport, Zachary A.; Haneef, Hamna F.; Anand, Sajant; Waldrip, Matthew; Jurchescu, Oana D. (2018-08-17). "Tutorial: Organic field-effect transistors: Materials, structure and operation". Journal of Applied Physics. 124 (7): 071101. Bibcode:2018JAP...124g1101L. doi:10.1063/1.5042255. ISSN 0021-8979. S2CID 116392919.
- ^ Jariwala, Deep; Sangwan, Vinod K.; Lauhon, Lincoln J.; Marks, Tobin J.; Hersam, Mark C. (2013-03-11). "Carbon nanomaterials for electronics, optoelectronics, photovoltaics, and sensing". Chemical Society Reviews. 42 (7): 2824–2860. arXiv:1402.0046. doi:10.1039/C2CS35335K. ISSN 1460-4744. PMID 23124307. S2CID 26123051.
- ^ Lin, Yen-Hung; Pattanasattayavong, Pichaya; Anthopoulos, Thomas D. (2017). "Metal-Halide Perovskite Transistors for Printed Electronics: Challenges and Opportunities". Advanced Materials. 29 (46): 1702838. Bibcode:2017AdM....2902838L. doi:10.1002/adma.201702838. hdl:10754/625882. ISSN 1521-4095. PMID 29024040. S2CID 205281664.
- ^ Thomas, Stuart R.; Pattanasattayavong, Pichaya; Anthopoulos, Thomas D. (2013-07-22). "Solution-processable metal oxide semiconductors for thin-film transistor applications". Chemical Society Reviews. 42 (16): 6910–6923. doi:10.1039/C3CS35402D. ISSN 1460-4744. PMID 23770615.
- ^ Teichler, Anke; Perelaer, Jolke; Schubert, Ulrich S. (2013-02-14). "Inkjet printing of organic electronics – comparison of deposition techniques and state-of-the-art developments". Journal of Materials Chemistry C. 1 (10): 1910–1925. doi:10.1039/C2TC00255H. ISSN 2050-7534.
- ^ Bashir, Aneeqa; Wöbkenberg, Paul H.; Smith, Jeremy; Ball, James M.; Adamopoulos, George; Bradley, Donal D. C.; Anthopoulos, Thomas D. (2009). "High-Performance Zinc Oxide Transistors and Circuits Fabricated by Spray Pyrolysis in Ambient Atmosphere". Advanced Materials. 21 (21): 2226–2231. Bibcode:2009AdM....21.2226B. doi:10.1002/adma.200803584. hdl:10044/1/18897. ISSN 1521-4095. S2CID 137260075.
- ^ Bonnassieux, Yvan; Brabec, Christoph J.; Cao, Yong; Carmichael, Tricia Breen; Chabinyc, Michael L.; Cheng, Kwang-Ting; Cho, Gyoujin; Chung, Anjung; Cobb, Corie L.; Distler, Andreas; Egelhaaf, Hans-Joachim (2021). "The 2021 flexible and printed electronics roadmap". Flexible and Printed Electronics. 6 (2): 023001. doi:10.1088/2058-8585/abf986. hdl:10754/669780. ISSN 2058-8585. S2CID 235288433.
- ^ Brotherton, S. D. (2013). Introduction to Thin Film Transistors: Physics and Technology of TFTs. Springer International Publishing. ISBN 978-3-319-00001-5.
- ^ Kamiya, Toshio; Hosono, Hideo (2010). "Material characteristics and applications of transparent amorphous oxide semiconductors". NPG Asia Materials. 2 (1): 15–22. doi:10.1038/asiamat.2010.5. ISSN 1884-4057.
- ^ Nomura, Kenji; Ohta, Hiromichi; Ueda, Kazushige; Kamiya, Toshio; Hirano, Masahiro; Hosono, Hideo (2003-05-23). "Thin-Film Transistor Fabricated in Single-Crystalline Transparent Oxide Semiconductor". Science. 300 (5623): 1269–1272. Bibcode:2003Sci...300.1269N. doi:10.1126/science.1083212. PMID 12764192. S2CID 20791905.
- ^ Wager, John. OSU Engineers Create World's First Transparent Transistor Archived 2007-09-15 at the Wayback Machine. College of Engineering, Oregon State University, Corvallis, OR: OSU News & Communication, 2003. 29 July 2007.
- ^ Fortunato, E. M. C.; Barquinha, P. M. C.; Pimentel, A. C. M. B. G.; Gonçalves, A. M. F.; Marques, A. J. S.; Pereira, L. M. N.; Martins, R. F. P. (March 2005). "Fully Transparent ZnO Thin-Film Transistor Produced at Room Temperature". Advanced Materials. 17 (5): 590–594. Bibcode:2005AdM....17..590F. doi:10.1002/adma.200400368. S2CID 137441513.
- ^ Fortunato, E.; Correia, N.; Barquinha, P.; Pereira, L.; Goncalves, G.; Martins, R. (September 2008). "High-Performance Flexible Hybrid Field-Effect Transistors Based on Cellulose Fiber Paper" (PDF). IEEE Electron Device Letters. 29 (9): 988–990. Bibcode:2008IEDL...29..988F. doi:10.1109/LED.2008.2001549. hdl:10362/3242. S2CID 26919164.
- ^ Chang, Ting-Kuo; Lin, Chin-Wei; Chang, Shihchang (2019). "39-3: Invited Paper: LTPO TFT Technology for AMOLEDs†". Sid Symposium Digest of Technical Papers. 50: 545–548. doi:10.1002/sdtp.12978. S2CID 191192447.
- ^ Chen, Qian; Su, Yue; Shi, Xuewen; Liu, Dongyang; Gong, Yuxin; Duan, Xinlv; Ji, Hansai; Geng, Di; Li, Ling; Liu, Ming (2019). "P-1.1: A New Compensation Pixel Circuit with LTPO TFTS". Sid Symposium Digest of Technical Papers. 50: 638–639. doi:10.1002/sdtp.13595. S2CID 210522411.
- ^ Luo, Haojun; Wang, Shaowen; Kang, Jiahao; Wang, Yu-Min; Zhao, Jigang; Tsong, Tina; Lu, Ping; Gupta, Amit; Hu, Wenbing; Wu, Huanda; Zhang, Shengwu; Kim, Jiha; Chiu, Chang Ming; Lee, Bong-Geum; Yuan, Ze; Yu, Xiaojun (2020). "24-3: Complementary LTPO Technology, Pixel Circuits and Integrated Gate Drivers for AMOLED Displays Supporting Variable Refresh Rates". Sid Symposium Digest of Technical Papers. 51: 351–354. doi:10.1002/sdtp.13876. S2CID 225488161.
- ^ https://www.corning.com/media/worldwide/global/documents/Markets_Display_Wager%20Information%20Display%202020.pdf [bare URL PDF]
- ^ Advances in Semiconductor Technologies: Selected Topics Beyond Conventional CMOS. John Wiley & Sons. 11 October 2022. ISBN 978-1-119-86958-0.
- ^ Brotherton, S. D. (2013). Introduction to Thin Film Transistors: Physics and Technology of TFTs. Springer Science & Business Media. p. 74. ISBN 9783319000022.
- ^ Woodall, Jerry M. (2010). Fundamentals of III-V Semiconductor MOSFETs. Springer. pp. 2–3. ISBN 9781441915474.
- ^ Brody, T. P.; Kunig, H. E. (October 1966). "A HIGH-GAIN InAs THIN-FILM TRANSISTOR". Applied Physics Letters. 9 (7): 259–260. Bibcode:1966ApPhL...9..259B. doi:10.1063/1.1754740. ISSN 0003-6951.
- ^ Weimer, Paul K. (June 1962). "The TFT A New Thin-Film Transistor". Proceedings of the IRE. 50 (6): 1462–9. doi:10.1109/JRPROC.1962.288190. ISSN 0096-8390. S2CID 51650159.
- ^ a b c d e f Kuo, Yue (1 January 2013). "Thin Film Transistor Technology—Past, Present, and Future" (PDF). The Electrochemical Society Interface. 22 (1): 55–61. Bibcode:2013ECSIn..22a..55K. doi:10.1149/2.F06131if. ISSN 1064-8208.
- ^ Lojek, Bo (2007). History of Semiconductor Engineering. Springer. pp. 322–4. ISBN 978-3540342588.
- ^ Richard Ahrons (2012). "Industrial Research in Microcircuitry at RCA: The Early Years, 1953–1963". IEEE Annals of the History of Computing. 12 (1): 60–73.
- ^ a b c d Kawamoto, H. (2012). "The Inventors of TFT Active-Matrix LCD Receive the 2011 IEEE Nishizawa Medal". Journal of Display Technology. 8 (1): 3–4. Bibcode:2012JDisT...8....3K. doi:10.1109/JDT.2011.2177740. ISSN 1551-319X.
- ^ Castellano, Joseph A. (2005). Liquid Gold: The Story of Liquid Crystal Displays and the Creation of an Industry. World Scientific. pp. 41–2. ISBN 9789812389565.
- ^ Brody, T. Peter; Asars, J. A.; Dixon, G. D. (November 1973). "A 6 × 6 inch 20 lines-per-inch liquid-crystal display panel". IEEE Transactions on Electron Devices. 20 (11): 995–1001. Bibcode:1973ITED...20..995B. doi:10.1109/T-ED.1973.17780. ISSN 0018-9383.
- ^ a b c d Souk, Jun; Morozumi, Shinji; Luo, Fang-Chen; Bita, Ion (2018). Flat Panel Display Manufacturing. Wiley. pp. 2–3. ISBN 9781119161356.
- ^ Comber, P. G. le; Spear, W. E.; Ghaith, A. (1979). "Amorphous-silicon field-effect device and possible application". Electronics Letters. 15 (6): 179–181. Bibcode:1979ElL....15..179L. doi:10.1049/el:19790126. ISSN 0013-5194.
- ^ a b Castellano, Joseph A. (2005). Liquid Gold: The Story of Liquid Crystal Displays and the Creation of an Industry. World Scientific. pp. 180, 181, 188. ISBN 9789812565846.
- ^ Morozumi, Shinji; Oguchi, Kouichi (12 October 1982). "Current Status of LCD-TV Development in Japan". Molecular Crystals and Liquid Crystals. 94 (1–2): 43–59. doi:10.1080/00268948308084246. ISSN 0026-8941.
- ^ US6580129B2, Lui, Basil; Migliorato, Piero & Yudasaka, Ichio et al., "Thin-film transistor and its manufacturing method", issued 2003-06-17
- ^ US6548356B2, Lui, Basil; Migliorato, Piero & Yudasaka, Ichio et al., "Thin film transistor", issued 2003-04-15
- ^ Kimura, Mutsumi; Inoue, Satoshi; Shimoda, Tatsuya; Lui, Basil; French, William; Kamohara, Itaru; Migliorato, Piero (2001). "Development of poly-Si TFT models for device simulation: In-plane trap model and thermionic emission model". SID Conference Record of the International Display Research Conference (in Japanese): 423–426. ISSN 1083-1312.
- ^ "ET-10". Epson. Retrieved 29 July 2019.
- ^ Mimura, Akio; Oohayashi, M.; Ohue, M.; Ohwada, J.; Hosokawa, Y. (1986). "SOI TFT's with directly contacted ITO". IEEE Electron Device Letters. 7 (2): 134–6. Bibcode:1986IEDL....7..134M. doi:10.1109/EDL.1986.26319. ISSN 0741-3106. S2CID 36089445.
- ^ Sunata, T.; Yukawa, T.; Miyake, K.; Matsushita, Y.; Murakami, Y.; Ugai, Y.; Tamamura, J.; Aoki, S. (1986). "A large-area high-resolution active-matrix color LCD addressed by a-Si TFT's". IEEE Transactions on Electron Devices. 33 (8): 1212–1217. Bibcode:1986ITED...33.1212S. doi:10.1109/T-ED.1986.22644. ISSN 0018-9383. S2CID 44190988.
- ^ Sunata, T.; Miyake, K.; Yasui, M.; Murakami, Y.; Ugai, Y.; Tamamura, J.; Aoki, S. (1986). "A 640 × 400 pixel active-matrix LCD using a-Si TFT's". IEEE Transactions on Electron Devices. 33 (8): 1218–21. Bibcode:1986ITED...33.1218S. doi:10.1109/T-ED.1986.22645. ISSN 0018-9383. S2CID 6356531.
- ^ Nagayasu, T.; Oketani, T.; Hirobe, T.; Kato, H.; Mizushima, S.; Take, H.; Yano, K.; Hijikigawa, M.; Washizuka, I. (October 1988). "A 14-in.-diagonal full-color a-Si TFT LCD". Conference Record of the 1988 International Display Research Conference. pp. 56–58. doi:10.1109/DISPL.1988.11274. S2CID 20817375.
- ^ Orland, Kyle (August 8, 2019). "What Sharp's IGZO display technology will mean for the Nintendo Switch". Ars Technica.
- ^ "IGZO Display Technology - Sharp". www.sharpsma.com.
- ^ Biggs, John; et al. (July 21, 2021). "A natively flexible 32-bit Arm microprocessor". Nature. 595 (7868): 532–6. Bibcode:2021Natur.595..532B. doi:10.1038/s41586-021-03625-w. PMID 34290427.